ING AND SANITIZING THE ICE MAKING SYSTEM
Ice makkny system:
: [-,p , r:1111;3rals rejected from the circulating water WARNING: Most ICF machlne cleaners are cltrlc or phosphoric
~i:~~~;ri:! the freezing cycle wili eventually form a acid which can cause lrrltatlon even after dllutlon In case of
f,a:c! .;CJi'*j deposit in the water system which pre- contact with eyes flush eyes thoroughly with fresh water and
,,t:.;rj a ;spid release of the ice. contact a physicIan lmrnedlately In case of contact with skin.
rinse well with water If swallowed, give large amounts of water
and contact a physIcIan lmmedlately Do not Induce vomltlng
i.ri-a:i 1c.e ;:i:,C; water system periodically to remove
KEEP OUT OF REACH OF CHILDREN
:i.ie?a, 3 i: li I ? build-up. Frequency of cleaning
&per& on ?water hardness. With soft water, clean-
!I:!% I:~ ay not be required for several years. With 6. Pour % gallon (1.9 L) of hot tap water into the
?~;~ro Ni2:t)r (15 to 20 grains/gal.) cleaning may be water pan and turn the service or cycle switch to
~~:~r~,ire! i as frequently as every six months. ?CLEAN.? This warms up the system to make the
cleaning solution more effective. Let circulate for
ii~~ c!ea.t and sanitize, loliow this procedure.* five minutes. While tap water is circulating, prepare
- -. .-..- -.
cleaning solution. Mix:
-~,c:c.~p!ec: ny the Natronal Sanitation Foundation. 6 oz. (1709) powdered citric, or phosphoric
acid into
d :I j I _ ,. ?+ ?P CI~ service :,wrtch In ?OFF? posrtron
% gallon (1.9 L) hot water
(Citric and phosphoric acid crystais are available
from many pharmacies or scientific supply houses.)
Commercial Ice Machine cleaners (liquid) are also
available from your dealer or refrigeration parts
supply stores. Mix according to instructions on
label (total quantity % gallon [I .9 L.1 1.
7. Turn Service or Cycle switch to ?OFF? and
drain tap water. (See step 5.)
8. Turn the switch to ?CLEAN? and slowly pour
the hot cleaning solution into the water pan. (If
FIGURE 4 the solution foams while pouring, wait until
foaming stops.) Then add the balance of the
1L F!r,rr-:.,ve rhe two thumb screws and slide the ice solution.
c:! ;:.er gr?d out of the two slots near the water pan.
Allow solution to circulate unti! the scale has
:i I_ ,? : :j I I ?., i !i e erectrical h,:rness. dissoived (15 to 30 minutes). Severe scale build-up
may require repeated cleaning with a fresh quantity
,L?, * j c~: o;? [he gr-rd should be melted under running of cleaning solution.
..?,:-r~r .ha?tjr Attempting to pick the ice slab off
i <; c: j i? ?pY:;/ stretch and damage grid wires. To clean scale off the side flanges of the freezing
plate, use rubber gloves and scrub with a plastic
G ri p.:. b?k: ctll ice from the storage bin and the scrubby or nonsoap filled stainless steel pad dipped
6 br?i:/Li\:j ,,!;jt?
in cleaning solution.
,-j:\ 1 Itie water pan by removing the drain plug 9. Drain the cleaning solution. Using the rubber
iii.; ?11 ;:r;d then re gloves, remove the drain plug and set the switch to
?OFF.?
10. Replace the pluq and add % gallon (1.9 L) of
fresh water. Set switch to clean, circulate five
minutes, drain. Repeat rinsing process.
HUM0 SCREWS
INTO DRAIN
FIG; ,RE 5 |
ACEC
