MAINTENANCE
Starter deviceTensioning the recoil spring
WARNING!Y Lift the starter cord up in the
notch on the starter pulley
!and turn the starter pulley 2
Y When the recoil spring is assembled in the starterturns clockwise.
housing, it is in tensioned position and can when
treated carelessly, pop out and cause injuries.NOTE! Check that the
Y Always be careful, when changing the recoil spring orstarter pulley can be turned
the starter cord. Always wear safety goggles for eyeat least half a turn, when the
protection.starter cord is entirely pulled
out.
Changing a broken or worn
starter cord
Changing the broken recoil spring
Y Lift the starter pulley. (See
Y Loosen the screws, that�Changing a broken or worn
hold the starter devicestarter cord�). The recoil
against the crankcase andspring is disassembled from
remove the starter device.the starter device, with its
inside facing down. Tap the
starter lightly against a
working bench or similar.
Y Put a new recoil spring in
Y Pull out the cord approx. 30the right position. If the
cm and lift it up into thespring pops out when
notch in the pulley. Zero-setassembling, it should be
the recoil spring by lettingmounted again, out and in
the pulley rotate slowly
towards the centre.
backwards. Undo the screw
in the centre of the pulley
Y Lubricate the recoil spring
and remove the pulley.
with thin oil. Assemble the
starter pulley, and tension
the recoil spring.
Y Insert and fasten a new
starter cord in the pulley.
Wind approx. 3 turns of the
starter cord on to the pulley.
Assemble the starter pulley
against the recoil spring, soStarter device assembly
the end of the spring
engages to the pulley. FitY Assemble the starter
the screw in the centre ofdevice, by pulling the starter
the pulley. Carry the startercord out first, then place the
cord through the hole in thestarter against the
starter housing and thecrankcase. Then slowly
starter handle. Make a knotrelease the starter cord so
on the starter cord.that the pulley engages with
the pawls.
Y Assemble and tighten the
screws, which hold the
starter.
30 � English |
ACEC
HUSQVARNA
